Rinnai RC98HPI Installation Manual

— Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. — WHAT TO DO IF YOU SMELL GAS

10 Manual - Rinnai Condensing Water Heaters Setting the Water Volume 1. Press the “Priority” button. 2. Press the “Water Smart Bath Fill” button t

Manual - Rinnai Condensing Water Heaters 11 Setting Controller to Mute To eliminate the beeps when keys are pressed or to turn th

12 Manual - Rinnai Condensing Water Heaters WARNING Turn off the electrical power supply, the manual gas valve and the manual water control val

Manual - Rinnai Condensing Water Heaters 13 Error Codes The Rinnai water heater has the ability to check its own operation continuously. If a fau

14 Manual - Rinnai Condensing Water Heaters Code Fault Remedy 16 Over Temperature Warning Check for restrictions in air flow around unit and vent

Manual - Rinnai Condensing Water Heaters 15 Trouble Shooting for Common Issues I don’t have any hot water when I open the tap. M

16 Manual - Rinnai Condensing Water Heaters Flushing the Heat Exchanger (Error Code: LC or 00) An “LC” or “00” error code indicates the un

Manual - Rinnai Condensing Water Heaters 17 Only properly trained and qualified installers should install this appliance. The warranty may be voi

18 Manual - Rinnai Condensing Water Heaters Clearances from Appliance 1. Identify the installation location and confirm that the in

Manual - Rinnai Condensing Water Heaters 19 Gas Piping General Instructions • A manual gas control valve must be placed in

2 Manual - Rinnai Condensing Water Heaters Specifications ... 3 Consumer Safety Information Safe

20 Manual - Rinnai Condensing Water Heaters Pipe Sizing Procedure - Example Gas Piping The gas supply must be capable of handl

Manual - Rinnai Condensing Water Heaters 21 The freeze protection features include electrical heating elements. Freeze protection may be disabled

22 Manual - Rinnai Condensing Water Heaters If the water heater is not going to be used during a period of possible freezing weather, it is recommen

Manual - Rinnai Condensing Water Heaters 23 Recommended Piping for Basic Installation GasSupply3/4"ColdWaterSupplyLine3/4"

24 Manual - Rinnai Condensing Water Heaters Recommended Piping for Circulation Systems Pressure Relief Valve3/4" Ball Valve3/4"

Manual - Rinnai Condensing Water Heaters 25 Optional Piping for Circulation Systems Pressure Relief Valve3/4" Ball Valve3/4&qu

26 Manual - Rinnai Condensing Water Heaters Venting Instructions • This water heater is a direct vent water heater and therefore

Manual - Rinnai Condensing Water Heaters 27 Example: If you have one elbow then your maximum vent length is 35 feet (10.7 m). If your actual len

28 Manual - Rinnai Condensing Water Heaters Flue Terminal Clearances (ANS Z21.10.3, CSA 4.3) INSIDECORNER DETAILFIXEDCLOSEDOPERABLEFI

Manual - Rinnai Condensing Water Heaters 29 24"V Additional Clearances - Vent Terminal (RC80HPi, RC98HPi) Local codes supersede these

Manual - Rinnai Condensing Water Heaters 3 Specifications Rinnai is continually updating and improving products. Therefore, specifications are su

30 Manual - Rinnai Condensing Water Heaters 2"36"12"INSIDECORNER Additional Clearances (RC80HPe, RC98HPe) Local codes super

Manual - Rinnai Condensing Water Heaters 31 Flue Installation (RC80HPi, RC98HPi) Secure the first vent component to the water heater

32 Manual - Rinnai Condensing Water Heaters High Altitude Installations 0-2000 ft (0-610 m) 2001-5200 ft (610-1585 m) 5201-7700 f

Manual - Rinnai Condensing Water Heaters 33 The conversion shall be carried out by a manufacturer’s authorized rep-resentative, in accordance wi

34 Manual - Rinnai Condensing Water Heaters Temperature Controller Installation • The controller should be out of reach of small

Manual - Rinnai Condensing Water Heaters 35 Temperature Controller Installation 1. Determine a suitable location for the contro

36 Manual - Rinnai Condensing Water Heaters Operating Instructions FOR YOUR SAFETY READ BEFORE OPERATING A. This appliance does

Manual - Rinnai Condensing Water Heaters 37 Technical Data Pressure Drop Curve Outlet Flow Data RC98HP Wate

38 Manual - Rinnai Condensing Water Heaters Space Heating If the water heater is to be used for both water (potable) heating an

Manual - Rinnai Condensing Water Heaters 39 Dimensions DIM DESCRIPTION RC80HPi in (mm) A Width 18.5 (470) B Depth 10.5 (

4 Manual - Rinnai Condensing Water Heaters WARNING Safety Behavior and Practices • Keep the area around the appliance clear

40 Manual - Rinnai Condensing Water Heaters Ladder Diagram WATER LEVEL DETECTING CIRCUIT WATER LEVEL ELECTRODE TWIN THERMISTOR

Manual - Rinnai Condensing Water Heaters 41 NOTICE BEFORE INSTALLATION Rinnai direct-vent appliance must be installed by a state qualified or lic

42 Manual - Rinnai Condensing Water Heaters What is covered? This Warranty covers any defects in materials or workmanship when the product is instal

Manual - Rinnai Condensing Water Heaters 43 What will Rinnai do? Rinnai will repair or replace the covered product or any part or component that i

44 Manuel – Rinnai Condensing Water Heaters — Ne pas entreposer ni utiliser d'essence ou ni d'autres vapeurs ou liquides inflammables à p

Manuel – Rinnai Condensing Water Heaters 45 Comportements et pratiques de sécurité Réglage de température Instructi

46 Manuel – Rinnai Condensing Water Heaters Plages de température avec un contrôleur de température Ce chauffe-eau va tenter de fournir de

Manuel – Rinnai Condensing Water Heaters 47 AVERTISSEMENT Coupez l'alimentation électrique, et fermez l'arrivée de gaz et d'ea

48 Manuel – Rinnai Condensing Water Heaters Seuls des installateurs qualifiés avec une formation adéquate peuvent installer cet appareil. La garanti

Manuel – Rinnai Condensing Water Heaters 49 to sideto frontto topto floor/ground Écartements par rapport à l'appareil 1. I

Manual - Rinnai Condensing Water Heaters 5 The Rinnai water heater is one of the most advanced water heaters available. It provides a continuous

50 Manuel – Rinnai Condensing Water Heaters Installations à haute altitude Pour les installations de U.S., reportez-vous aux instruc

Manuel – Rinnai Condensing Water Heaters 51 • Une vanne manuelle de coupure de gaz doit être placée sur la conduite d'alimentation en gaz en

52 Manuel – Rinnai Condensing Water Heaters Tuyauterie d'eau • Une vanne manuelle de coupure d'eau doit intercalée sur

Manuel – Rinnai Condensing Water Heaters 53 GasSupply3/4"ColdWaterSupplyLine3/4" Hot Water Supply LineRinnaiEquipment ListRinnaiWater He

54 Manuel – Rinnai Condensing Water Heaters • Employez seulement le passage qui est approuvé et identifié comme acceptable pour les appareils de co

Manuel – Rinnai Condensing Water Heaters 55 Nombre de coudes à 90° 0 1 2 3 4 5 6 41 ft 1 (12.5 m) 35 ft 2 (10.7 m) 29 ft 3 (8.8 m) 23 ft

56 Manuel – Rinnai Condensing Water Heaters Contacts avec les constructeurs de ventilation pour des informations d'installation et de liste de

Manuel – Rinnai Condensing Water Heaters 57 Espacement pour terminaison de cheminée INSIDECORNER DETAI LFIXEDCLOSEDOPERABLEFIXEDCLOSEDOPERAB

58 Manuel – Rinnai Condensing Water Heaters Fixez la pièce de ventilation connectée sur le chauffe-eau avec une vis autotaraudeuse dans le trou situ

Manuel – Rinnai Condensing Water Heaters 59 Instructions d'utilisation À LIRE AVANT LA MISE EN SERVICE POUR VOTRE SÉCURITÉ

6 Manual - Rinnai Condensing Water Heaters Temperature Controllers - Models MC-91-1US & MCC-91-1US MC-502RC-1US-S * (Wireless) *

60 Manuel – Rinnai Condensing Water Heaters Diagramme en escalier PHASE NEUTRE CONTACT DE DÉTECTION DE GEL FUSIBLE 7 A ANTI-FOUDRE

Manuel – Rinnai Condensing Water Heaters 61 Support à la clientèle Qu'est-ce qui est couvert ? Cette garantie couvre tous défauts dus aux ma

62 Manuel – Rinnai Condensing Water Heaters Que fait Rinnai pour exercer la garantie ? Rinnai va réparer ou remplacer le produit, ou toute partie o

Manual - Rinnai Condensing Water Heaters 63 Notes

060 00012 30202 8Rinnai’s other fine products Rinnai America Corporation 103 International Drive Peachtree City, GA 30269 TOLL FREE: 1-800-621-9419 FA

Manual - Rinnai Condensing Water Heaters 7 MC-100V-1US BC-100V-1US The BC-100V controller is water resistant. Avoid splashing the controller. NOT

8 Manual - Rinnai Condensing Water Heaters How to Set the Temperature 1. If the water heater is off, press the ON/OFF button to tur

Manual - Rinnai Condensing Water Heaters 9 Suggested temperatures are • Kitchen 120 ºF (49º C) • Shower 98º - 110º F (37º - 43º C) • Bath Fil