Rinnai RL75E User Manual Page 1

— Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. — WHAT TO DO IF YOU SMELL GAS

10 VB Series Outdoor LS Manual Setting Controller to Mute To eliminate the beeps when keys are pressed or to turn the beeps back on

VB Series Outdoor LS Manual 11 WARNING Turn off the electrical power supply, the manual gas valve and the manual water control valve whenever

12 VB Series Outdoor LS Manual Error Codes The Rinnai water heater has the ability to check its own operation continuously. If a fault occurs, an e

VB Series Outdoor LS Manual 13 Error Codes Code Fault Remedy 16 Over Temperature Warning Check for restrictions in air flow around unit and vent

14 VB Series Outdoor LS Manual Trouble Shooting for Common Issues I don’t have any hot water when I open the tap. Make sure there

VB Series Outdoor LS Manual 15 Water HeaterPressure Relief Valve3/4" Ball Valve3/4" UnionCheck ValveSPressure RegulatorCirculating PumpS

16 VB Series Outdoor LS Manual Only properly trained and qualified installers should install this appliance. The warranty may be voided due to impr

VB Series Outdoor LS Manual 17 Environment Air surrounding the water heater, venting, and vent termination(s) is used for combustion and m

18 VB Series Outdoor LS Manual Clearances from Appliance 1. Identify the installation location and confirm that the installation wi

VB Series Outdoor LS Manual 19 Gas Piping General Instructions • A manual gas control valve must be placed in the gas suppl

2 VB Series Outdoor LS Manual Specifications ... 3 Consumer Safety Information Safety Definitions

20 VB Series Outdoor LS Manual Pipe Sizing Procedure - Example Pipe Size (inches) 3/4 1 1 1/4 1 1/2 10 273 514 1060 1580 20 188 353 726 1090 30 1

VB Series Outdoor LS Manual 21 Isolation Valves and Pressure Relief Valve (RL75e and RL94e) Water Piping The isolation valve

22 VB Series Outdoor LS Manual The freeze protection features include electrical heating elements. Freeze protection may be disabled if electricity

VB Series Outdoor LS Manual 23 If the water heater is not going to be used during a period of possible freezing weather, it is recommended that th

24 VB Series Outdoor LS Manual Pressure Relief Valve3/4" Ball Valve3/4" UnionCheck ValveSPressure RegulatorCirculating PumpSolenoid ValveB

VB Series Outdoor LS Manual 25 Recommended Piping for Basic Installation GasSupply3/4"ColdWaterSupplyLine3/4" Hot Water Sup

26 VB Series Outdoor LS Manual Recommended Piping for Circulation Systems Pressure Relief Valve3/4" Ball Valve3/4" UnionCheck

VB Series Outdoor LS Manual 27 FIXEDCLOSEDOPERABLEFIXEDCLOSEDOPERABLEBBBAJBIMCFBBEDLGAHK Flue Terminal Clearances (ANS Z21.10.3, CSA 4.3)

28 VB Series Outdoor LS Manual Additional Clearances Local codes supersede these clearances. • Avoid termination locations near

VB Series Outdoor LS Manual 29 High Altitude Installations 0-2000 ft (0-610 m) 2001-5200 ft (610-1585 m) 5201-7700 ft (1585-234

VB Series Outdoor LS Manual 3 Specifications Model RL75e RL94e R98LSe R98LSe-ASME Minimum Gas Consumption Btu/h 9,900 (NG) 10,300 (LPG) 19,00

30 VB Series Outdoor LS Manual The conversion shall be carried out by a manufacturer’s authorized rep-resentative, in accordance with the requirem

VB Series Outdoor LS Manual 31 Temperature Controller Installation • The controller should be out of reach of small children. •

32 VB Series Outdoor LS Manual Temperature Controller Installation 1. Determine a suitable location for the controller. 2. Make

VB Series Outdoor LS Manual 33 Operating Instructions FOR YOUR SAFETY READ BEFORE OPERATING A. This appliance does not have a

34 VB Series Outdoor LS Manual 0 10 20 30 40 50 60 70 80 90 100 0 5 10 15 20 25 30 35 40 45 0 2 4 6 8 10 12 0.01.02.03.04.05.06.07.08.09.010.00 2550

VB Series Outdoor LS Manual 35 Space Heating If the water heater is to be used for both water (potable) heating and space hea

36 VB Series Outdoor LS Manual Dimensions DIM DESCRIPTION RL75e RL94e in (mm) R98LSe R98LSe-ASME in (mm) A Width 14 (355.6)

VB Series Outdoor LS Manual 37 Ladder Diagram (for RL75e and RL94e)

38 VB Series Outdoor LS Manual Ladder Diagram (for R98LSe and R98LSe-ASME) RELAY 1IGFROST SENSINGSWITCHANTI-FROST HEATERIGNITIONCOMBUSTION

VB Series Outdoor LS Manual 39 What is covered? This Warranty covers any defects in materials or workmanship when the product is installed and ope

4 VB Series Outdoor LS Manual WARNING Safety Behavior and Practices • Keep the area around the appliance clear and free fro

40 VB Series Outdoor LS Manual What will Rinnai do? Rinnai will repair or replace the covered product or any part or component that is defective in

VB Series Outdoor LS Manual 41 NOTICE BEFORE INSTALLATION Rinnai direct-vent appliance must be installed by a state qualified or licensed contrac

42 Manuel – Chauffe-eau d’extérieur série VB LS — Ne pas entreposer ni utiliser d'essence ou ni d'autres vapeurs ou liquides inflammables

Manuel – Chauffe-eau d’extérieur série VB LS 43 Comportements et pratiques de sécurité Réglage de température Instr

44 Manuel – Chauffe-eau d’extérieur série VB LS Plages de température avec un contrôleur de température Ce chauffe-eau va tenter de fournir

Manuel – Chauffe-eau d’extérieur série VB LS 45 AVERTISSEMENT Coupez l'alimentation électrique, et fermez l'arrivée de gaz et d&apo

46 Manuel – Chauffe-eau d’extérieur série VB LS Seuls des installateurs qualifiés avec une formation adéquate peuvent installer cet appareil. La gar

Manuel – Chauffe-eau d’extérieur série VB LS 47 Environnement Air entourant le chauffe eau, l'évacuation et l'évent termination(s

48 Manuel – Chauffe-eau d’extérieur série VB LS Écartements par rapport à l'appareil 1. Identifiez l'emplacement d&apo

Manuel – Chauffe-eau d’extérieur série VB LS 49 Raccordement électrique Le chauffe-eau doit être électriquement relié à la terre

VB Series Outdoor LS Manual 5 The Rinnai water heater is one of the most advanced water heaters available. It provides a continuous supply of hot

50 Manuel – Chauffe-eau d’extérieur série VB LS Installations à haute altitude Micro-commutateur 0-2000 ft (0-610 m) 2001-5200 ft (6

Manuel – Chauffe-eau d’extérieur série VB LS 51 Tuyauterie d'eau Valve à Bille / Valve de dégagement de pression (RL75e, R

52 Manuel – Chauffe-eau d’extérieur série VB LS Tuyauterie d'eau • Une vanne manuelle de coupure d'eau doit intercalée

Manuel – Chauffe-eau d’extérieur série VB LS 53 FIXEDCLOSEDOPERABLEFIXEDCLOSEDOPERABLEBBBAJBIMCFBBEDLGAHKDÉTAIL D'ANGLE INTÉRIEUR FERMETURE P

54 Manuel – Chauffe-eau d’extérieur série VB LS Tuyauterie recommandée pour installation de base GasSupply3/4"ColdWaterSupplyLine3/4&

Manuel – Chauffe-eau d’extérieur série VB LS 55 Instructions d'utilisation À LIRE AVANT LA MISE EN SERVICE POUR VOTRE SÉCU

56 Manuel – Chauffe-eau d’extérieur série VB LS Diagramme en escalier (RL75e, RL94e) PHASE NEUTRE CONTACT DE DÉTECTION DE GEL FUSIBLE

Manuel – Chauffe-eau d’extérieur série VB LS 57 Diagramme en escalier (R98LSe, R98LSeASME) RELAY 1IGFROST SENSINGSWITCHANTI-FROST

58 Manuel – Chauffe-eau d’extérieur série VB LS Support à la clientèle Qu'est-ce qui est couvert ? Cette garantie couvre tous défauts dus aux

Manuel – Chauffe-eau d’extérieur série VB LS 59 Que fait Rinnai pour exercer la garantie ? Rinnai va réparer ou remplacer le produit, ou toute pa

6 VB Series Outdoor LS Manual Temperature Controller MC-91-1US & MCC-91-1US The MC-91 controller is the standard temperature c

U287-1932X01(00)Printed in Japan VB2528WVB2735WVA3237W060 00012 30660 6

VB Series Outdoor LS Manual 7 How to Set the Temperature DANGER Hot water can be dangerous, especially for infants or ch

8 VB Series Outdoor LS Manual Setting the Sound Volume (Voice Prompt) BC-100V Press the “Sound Vol.” button to adjust the voice prompt

VB Series Outdoor LS Manual 9 Using the Water Smart / Bath Fill Function Overview This function is exclusive to the BC-100V temperatu